For want of a nail the shoe was lost.
For want of a shoe the horse was lost.
For want of a horse the rider was lost.
For want of a rider the message was lost.
For want of a message the battle was lost.
For want of a battle the kingdom was lost.
And all for the want of a horseshoe nail.
One of the biggest problems facing the individual in the field can be equipment failure (blowout). Whether it’s your LBE/LBV or ruck coming apart at critical stress points, or your boots deciding to blow out due to hard use, these issues can and will happen in the field. Considering the importance of your boots and your load bearing gear, having some items to perform hasty repairs is very important to the Survivalist.
Once, while training using a LBV-88 vest, I had the left rear adjustment buckle’s suspension webbing come completely apart (bar tack thread came apart on the upper/outer side) which caused the gear suspended from the left rear of the vest to hang at a terrible angle, and making it nearly impossible to move quietly. My improvised field repair consisted of using the awl on my German army pocket knife (didn’t buy a multi tool till about ’92) to put a hole through both sides of the strap which was threaded back through the adjustment/slider buckle, and then thread 550 cord through the webbing, looping it around to the left, then back through again, looping it the opposite way, and tying it off with a square knot, and burning/melting the knot fast (this took about 10 minutes). Usually if load bearing gear needs repaired immediately, it’s the webbing straps which comprise most of the weight bearing material in and LBE or LBV.
550 cord saved the day, and is one of the best things you can carry in your gear for field repairs, shelter building, trap construction, and any other use that might come to mind. Besides the cord being used whole for different projects, it can also be taken apart and used in other ways. If you have something that needs threaded, and the cord is too thick (such as the small pommel holes on some knives), you can remove the cords guts (seven strands of thinner thread), and it should go through the smaller hole diameter. Speaking of the inner strands of 550 cord. These threads make very good sewing thread if you have a larger needle with a big eye.
Usually, 550 cord will work to repair most field load bearing gear, but what about boots? I have had boots split the sole across the ball of my foot (especially in extreme cold weather), and I have had heels start to separate from the boot. Although 100 mph tape will suffice for finishing a short term task, the Survivalist might need more of an extension in the “short term repairs” department. I have used a few different types of materials for repairs, and this is what I’ve found that works.
For more specific repairs that involve the seam of your equipment or more than just temporary boot repair, nothing has worked better for me than “bank line” or some type of fishing line and a “Speedy Stitcher”. I have use them to repair nylon and canvas load bearing gear and boot seams (mostly the top of the heel cap behind you Achilles heel), and it will hold for some time before needing redone.
Another product I’ve used is ShoeGoo for sole reconstruction. The boot pictured that had partial heel separation is still going strong after the repair, and that was a year and a half ago. What I have done when I have to use ShoeGoo on the shoe’s sole, is apply the ShoeGoo to the damaged area, using something like a Popsicle stick or ink pen shaft to get it in as much of the area as possible. I then seal up the area with duct tape (preferably “Gorilla Tape” for it’s holding ability), and place a weight on the shoe till the ShoeGoo sets up. Is this an instant fix? No. If you need instantaneous repair for use, the only options you have are to get another pair of boots, or wrap the Hell out of it with 100 MPH tape (it does work BTW). If you have another pair of boots to use, go ahead and repair the boots as shown, since you don’t know when they might be needed, and procrastination on repairs like that will eventually bite you in the ass.